To Push or Not To Push...
During a recent podcast episode we read a listener question asking whether either one of us had ever been involved in a mishap. Co-host Sunshine regaled the listeners with the story about a time he encountered a dangerous situation on takeoff as a relatively new F/A-18 pilot. The account, reproduced below, was originally chronicled for the naval aviation safety magazine, Approach…
I was one of several fortunate FRSFleet Replacement Squadron. aka RAG. A US Navy training squadron that prepares pilots for operational service in fleet-specific aircraft. students to head to NAF El Centro, CA in the summer of 2006 for my strike detachment to learn how to bomb. El Centro, while hot (meaning high density altitude) routinely boasted no clouds and beautiful terrain for flying. My hiatus from aviation during graduate school in Monterey, California had made me completely incompatible with the desert clime. My respect for our Marine brethren in Yuma, AZ quadrupled as I burned my fingers during every start, from APUAuxiliary Power Unit. A small jet engine used to provide aircraft systems power (hydraulic, electrical, etc.). spool-up until both engines came online. The last time I had dealt with this kind of weather was in the Arabian Gulf in 2002, with the S-3B Viking’s TF-34 engines. In that platform, I had a true respect for the old “hot and heavy” situation which tests a pilot’s skills.
Although the VFA-106 instructors had thoroughly briefed me on engine performance degradation, and I had calculated takeoff performance data, I honestly thought the Hornet always would have excess thrust available. With a configuration of single centerline fuel tank and a few Mk 76 practice bombs, I assumed the aircraft would always have an abundance of thrust available so that my skills would not be tested—mistake #1.
So, there I was, waiting at the hold short with my lead–an exchange pilot from the UK–just moments from taking off for the practice bombing ranges. Like a good student, I rehearsed the mission and “switchology” in my mind. Due to the short transit, I knew it would be fast and furious once airborne. I had always thought of takeoff and rendezvous as quite mechanical and did not give much thought during my chair flying—mistake #2.
Holding short
We received tower clearance and set up for a standard 10-second interval take off on the westward runway. As I watched the lead race away, his plane looked distorted from the rising hot air–it made him look almost like a mirage. As I began to roll, I noticed his “mirage” took quite a lot of concrete to rotate. I took a final look at my engine gauges, then focused outside on the runway and my airspeed in the HUD. At just over calculated rotation speed, the plane picked itself off the deck. A split second later, however, I heard several loud successive bangs from my right engine. The aural warning system (affectionately termed B!tching Betty) blurted, “Engine right, Engine right,” as the plane began to yaw right. I steadied the plane and left both throttles in afterburner while hawking airspeed and altitude. I struggled to maintain 380 feet and 157 knots (three knots below calculated take-off speed) for a few lingering moments, while I “sucked up the seat cushion.”
I glanced down at the engine instruments and saw the right engine had rolled back to flight idle, despite my left hand still commanding A/B on both sides. I tried to push the throttles through the stops and had a white-knuckle grip on the stick. I also tried to curl my toes around the rudder pedal edges to maintain balanced flight. Just then, the rest of the emergency-takeoff procedure hit me: “External jettison button-push (if required).”
As my stem power invited a few more neurons to play, I realized I was flying over farms and buildings. I saw an open patch of desert at my one o’clock position and not terribly far. I decided to hold the jettison until that point so I wouldn’t ruin the day of anyone underneath my limping jet. Fleeting ideas of possible ejection caused me to straighten up in the seat and reassess the populated areas if the external jettison did not make a difference aerodynamically. As I wrestled with the plane for a few more excruciating seconds and said a prayer, from out of one of the darkest, dustiest corners in my mind the old Viking procedure for emergency takeoff came forth: I decided I could reduce parasitic drag a little by retracting the landing gear. Without a second thought, my left hand complied, and up came the gear. This was a small miracle as the hydraulics for gear retraction were only powered by the right engine… the failing engine. As the gear indicator lights extinguished, the airspeed crept up a few knots to a much more comfortable 165 knots. I now felt confident raising the nose a few degrees and started a gentle climb at about 162 knots with both throttles still in A/B. I prayed aloud again.
Passing 2,000 feet, I did my best impersonation of a cool, calm, and collected pilot and told tower of my emergency. I then asked for an emergency orbit pattern at 7,000 feet. I finally brought the right throttle back to flight idle and the instruments depicted the engine safely stable. The left throttle remained in A/B while I explained the situation to my lead. He immediately rejoined in loose cruise formation, and we went through the emergency procedures several times to ensure accuracy. I cracked a smile as he transmitted, “Let me know if you have to step out of the jet at any moment.” Only a Brit would use such a genteel expression to describe such a violent and undesirable act.
Once established at 7,000 feet, my next order of business was to set up for a short-field field arrested landing. Because I did not jettison the external tank, I had to dump a lot of gas to get down to landing weight. Unfortunately, I had to keep the left engine in A/B to maintain altitude, which brought me to my next dilemma: should I be dumping fuel from the mast dump which seemed only eight to 10 feet above my staged A/B? My fearless lead’s response was something along the lines of “I’m not quite sure, but I will move farther away.” Gee…thanks a pant-load,” I thought. It rained JP-5 in the desert that day and I subsequently took an uneventful trap on the duty runway.